Empower Your Steering The Definitive Guide to U-Joint Indexing

Most likely will have to take them apart and compare by measureling to Spicer PTO u joints. So strange for them to be loose as they get very little rotation ... (? not sure proper name). It shouldn't move out of place unless you grab your steering wheel when it is disconnected. I was able to use two tubes ... The u-joint on the steering column has free play in both directions (left/right and push/pull). It's not a huge amount, probably quarter inch in out, same left ... If this happens, index the u-joints two or three splines in one direction. The hard spot should disappear or be minimized. 5. Install the shaft or joint on the ... The shaft is also 1", and slides over the upper shaft (rectangular). I can't count the splines since there is a huge flat spot for indexing. I ... Rod and Custom Magazine go into detail on how to build your custom steering system from using universal joints (U-Joints) to the use of ... 2013 Audi Q5 steering column changing - steering column universal joint-u-joint ... How to Adjust and Eliminate Steering Play on the Steering ... 17) maneuver the joint and shaft back down into the lower engine bay near the rack, moving the steering column as needed forward and backwards. Pull the bolt out of the steering column at the top joint, turn slow and carefully and see if binding stops, and look for up/ down movement of that joint on ... Degreased and clearcoated the outside. Antiseize on the inside, blue loctite on threaded studs. Also replaced the original cheapo plastic ...